Char-Broil Patio Caddie Specifications download pdf (Page 6)

Safety Tips

sBefore opening LP tank valve, check the coupling nut for

tightness.

sWhen grill is not in use, turn off control knob and LP tank

valve.

sNever move grill while in operation or still hot.

sUse long-handled barbecue utensils and oven mitts to avoid

burns and splatters.

sThe grease cup must be attached to grease clip and emptied

after each use. Do not remove grease cup until grill has

completely cooled.

sIf you notice grease or other hot material dripping from grill

onto valve, hose or regulator, turn off gas supply at once.

Determine the cause, correct it, then clean and inspect valve,

hose and regulator before continuing. Perform a leak test.

sThe regulator may make a humming or whistling noise during

operation. This will not affect safety or use of grill.

sIf you have a grill problem see the "Troubleshooting Section".

• NEVER attempt to light burner with lid closed. A buildup

of non-ignited gas inside of closed grill is hazardous.

• Never operate grill with LP tank out of correct position

specified in assembly instructions.

• Always close LP tank valve and remove coupling nut

before moving LP tank from specified operating

position.

WARNING

CAUTION

• Putting out grease fires by closing the lid is not

possible. Grills are well ventilated for safety reasons.

• Do not use water on a grease fire. Personal injury may

result. If a grease fire develops, turn knobs and LP

tank off.

• Do not leave grill unattended while preheating or

burning off food residue on HI. If grill has not been

regularly cleaned, a grease fire can occur that may

damage the product.

WARNING

• Never attempt to attach this grill to the self-contained

LP gas system of a camper trailer or motor home.

• Do not use grill until leak-tested.

Hose Check

• Before each use, check to see if hoses are cut, worn or

kinked. Replace damaged hoses before using grill. Use only

valve/hose/regulator specified by manufacturer.

Normal

Hose

Kinked

Hose

Turning Grill Off

• Turn knob to OFF position. Turn LP tank hand wheel

clockwise to a full stop.

Ignitor Check

• Turn gas off at LP tank. Press ignitor button rapidly. “Click”

should be heard each time at electrode. See Troubleshooting

section if not click is heard.

Valve Check

• Important: Make sure gas is OFF at LP tank before

checking valve. Knob locks in place. To check valve, first

push in knob and release, knob should spring back. If knob

does not spring back, replace valve assembly before using

grill. Turn knob to LOW position then turn back to OFF

position. Valve should turn smoothly.

Before Your First Cookout

• Light burner, check to make sure it is lit, close the lid and warm

up grill on HIGH for 15 minutes. Curing of paint and parts will

produce an odor only on first lighting.

Burner Flame Check

1. Light burner in grill bottom using long-stem match as

described in Match Lighting.

2. Push in and rotate knob from HIGH to LOW. You should see

a noticeably smaller flame in LOW position from that seen in

HIGH position. Always check flame, as described above, prior

to each use

s Let grill cool before placing briquets.

Ignitor Lighting

sDo not lean over grill while lighting.

1. Open lid. Turn on gas at LP tank.

2. Push in and turn knob on control leg to HIGH.

3. Push IGNITOR button rapidly to light. Be sure burner lights

and stays lit.

4. If IGNITOR does not work, follow match lighting instructions.

CAUTION

If burner does not light, turn knob(s) to , wait 5

minutes, try again. If the burner does not ignite with the

valve open, gas will continue to flow out of the burner

and could accidentally ignite with risk of injury.

OFF

6 • 06601322

1 2 3 4 5 6 7 ... 20

Comments to this Manuals

No comments

Char-Broil Patio Caddie Specifications Page 6

Comments to this Manuals

Related products and manuals for Barbecues & grills Char-Broil Patio Caddie