Char-Broil 463720109 User's Guide download pdf (Page 12)

Turn controls and gas source or tank OFF when not

in use,

CAUTIo.

Burner Flame Check

• Light burner, rotate knobs from HIGH to LOW.You should see

a smaller flame in LOW position than seen on HIGH.Always

check flame prior to each use. If only low flame is seen refer to

"Sudden drop or low flame" in the Troubleshooting Section.

If ignition does NOT occur in 5 seconds, turn the

burner controls OFF,wait 5 minutes and repeat the

lighting procedure. If the burner does not ignitewith

the valve open, gas will continue to flow out of the

burner and could accidently ignite with risk of injury.

Match-Lighting

,A Do not lean over grill while lighting.

1. Open lid during lighting.

2. Place match into match holder (hanging from side of cart).

3. Push in and turn left knob to _,_ HIGH position. Be sure

burner lights and stays lit.

4. Light right burner by pushing knob in and turning to _ HIGH

position.

Sideburner ignitor Lighting

1. Turn OFF gas burner control valves.

2. Turn ON gas source or tank.

3. To ignite SIDEBURNER, open sideburner cover.

4. Turn sideburner knob to_: HIGH. and push IGNITOR

button rapidly.

5. If sideburner does not light in 5 seconds, turn knob to OFF,

wait 5 minutes, then repeat lighting procedure.

Sideburner Match Lighting

1. Turn on gas at LPtank.

2. Hold lit match to any port

on the burner. Push in

and turn sideburner knob

to _. Be sure burner

lights and stays lit.

Hose Check

• Before each use, check to see if hoses are cut, worn or kinked.

Replace damaged hoses before using grill. Use only

valve/hose/regulator specified in the Parts List.

Normal Kinked

Hose Hose

Turning Grill Off

• Turn all knobs to OFF position.Turn LPtank off by turning

OPD hand wheel clockwise to a full stop.

Ignitor Check

• Turn gas off at LP tank. Press and hold ignitor button. "Click"

should be heard and spark seen each time between collector

box or burner and electrodes. See "Troubleshooting"if no click

or spark.

Valve Check

• Important: Make sure gas is off at LP tank before checking

valves. Knobs lock in OFF position. To check valves, first

push in knobs and release, knobs should spring back. If knobs

do not spring back, replace valve assembly before using grill.

Turn knobs to LO position then turn back to OFF position.

Valves should turn smoothly.

1 2 ... 7 8 9 10 11 12 13 14 15 16 17 ... 31 32

Comments to this Manuals

No comments

Char-Broil 463720109 User's Guide Page 12

Comments to this Manuals

Related products and manuals for Barbecues & grills Char-Broil 463720109