Char-Broil 463270311 User's Guide

PRODUCT GUIDEMODEL 463270311 Serial NumberDate PurchasedIMPORTANT: Fill out the product record information below.See rating label on grill for serial

6.Turn the coupling nut clockwise and tighten to a full stop. The regulator will seal on the back-check feature in the LP cylinder valve, resulting in

WARNINGFor Safe Use of Your Grill and to Avoid Serious Injury:• Do not let children operate or play near grill. • Keep grill area clear and free from

Burner Flame Check• Remove cooking grates and flame tamers. Light burners, rotate knobs from HI to LOW. You should see a smaller flame in LOW position

Cleaning the Burner AssemblyFollow these instructions to clean and/or replace parts of burnerassembly or if you have trouble igniting grill.1. Turn g

This warranty only applies to units purchased from an authorized retailer. Manufacturer warrants to the original consumer-purchaser only that this pr

PARTS LISTNOTE: Some grill parts shown in the assembly steps may differ slightly in appearance from those on your particular grill model. However, the

PARTS DIAGRAM16QQNABCCDDEFGHILMNNYYOOYYPPPQYZZZZZYYYYJKRSTAABBCCDDFFEEEEGGHHIILLMMOOPPNNVVWWXXVJJKKSSTTRRUUUUUUUUVVSSXWU

21/4-20x1/2” screw1Attach side panels to bottom shelf using three 1/4-20x1/2” screws, 7mm lock washers, and 7mm flat washers per panel.IMPORTANT: Pane

34This step requires two people to lift and position grill head onto cart. Carefully lower the grill head onto the cart, aligning slots at bottom of g

On back of grill, place upper back panel between side panels and above lower back panel. Secure upper back panel, in lower holes, using one 1/4-20x1½”

1. Do not store or use gasoline or other flammable liquids or vapors in the vicinity of this or any other appliance.2. An LP cylinder not connected fo

7 20Now you may fully tighten lower screws on upper back panel.1/4-20x3/4”screwBack of main control panelControl panelFascia, left sideburner shelf

9Insert sideburner burner into left shelf.shelf, shown A.The stud on bottom of burner fits into rear small hole in sideburner drip pan onSecure burner

11Insert front brace under control panel and between cart side panels. Make sure door hinge pins are on the top side and facing the front. Secure usin

13Insert hinge pin on bottom of doors into hole in bottom shelf. Press upper hinge pin in front brace, align hinge hole on top of door, and release hi

1524Install flame tamers by sliding one end of each flame tamer into slots at front of firebox and resting opposite end on pins in back of firebox.Bac

. 1725LP CYLINDER IS SOLD SEPARATELY. Fill and leak check the cylinder before attaching to grill and regulator (see Use & Care section). Once cyli

–26AA BatteryElectronic Ignition Cap+-On back of grill, slide grease tray into opening in upper back panel.CAUTIONFailure to install grease tray will

EMERGENCIES: If a gas leak cannot be stopped, or a fire occurs due to gas leakage, call the fire department.EmergenciesProblemGas leaking from cracked

Troubleshooting (continued)ProblemBurner(s) will not light using ignitor.(See Electronic Ignition Troubleshooting also)Burner(s) will notmatch light.

Troubleshooting - Electronic IgnitionProblem (Ignition)SECTION INo sparks appear at any electrodes when Electronic Ignition Buttonis pressed; no noise

WARNINGCALIFORNIA PROPOSITION 651. Combustion by-products produced when using this product contain chemicals known to the State of California to cause

NOTES30

31 Warranty Registration DepartmentP.O. Box 1240Columbus, GA 31902-1240

First Time UseRead your Assembly Manual and ensure the grill is put together properly. Remove all Point-of-Purchase advertising material from all gri

Outdoor grilling is really quite simple. You'll succeed with burgers, dogs, or steaks usually on your very first try. With experience, you will

USDA Recommended Safe MinimumInternal TemperaturesBeef, Veal, Lamb, Steaks, & Roasts 145° FFish 145° FPork 160° FBeef, Veal, Lamb Ground 160° FEgg

Why Clean?We've all heard the saying 'An ounce of prevention is worth a pound of cure'. This is great advice when it comes to keeping

• NEVER store a spare LP cylinder under or near the appliance or in an enclosed area. • Never fill a cylinder beyond 80% full.• An over filled or impr

WARNINGIf “growing” bubbles appear do not use or move the LP cylinder. Contact an LP gas supplier or your fire department!Connecting Regulator to the