Char-Broil 463232011 User's Guide

Assembly instructions © 2010 PRODUCT GUIDEMODEL 463232011 © 2010 Char-Broil, LLC Columbus, GA 31902Printed in China Serial NumberDate Purcha

This warranty only applies to units purchased from an authorized retailer. Manufacturer warrants to the original consumer-purchaser only that this pr

PARTS LIST NOTE: Some grill parts shown in the assembly steps may differ slightly in appearance from those on your particular grill model. However, th

PARTS DIAGRAMQQ12 ABGHVWIFJCDEKMLLOOPPMMNNJJKKSUXYYAAYYRRZZZZTTSSSSAAAOPQQUUVVYYVVVVUUUUOORNWWAAAATCCEEDDHHFFIIGGXXLZZBBDC

21/4-20x1/2” screw1Attach side panels to bottom shelf using three 1/4-20x1/2” screws, 7mm lock washers, and 7mm flat washers per panel.IMPORTANT: Pane

34This step requires two people to lift and position grill head onto cart. Carefully lower the grill head onto the cart, aligning slots at bottom of g

On back of grill, place upper back panel between side panels and above lower back panel. Secure upper back panel, in lower holes, using one 1/4-20x1½

16 6Insert flange on right side shelf into side shelf brackets on side of firebox, shown B.flat washer, shown E.Attach front of shelf and fascia usin

177Now you may fully tighten lower screws on upper back panel.1/4-20x3/4”screwBack of main control panelControl panelFascia, left sideburner shelf

924Pull out the three knobs from control panel. Insert temperature gauge stem into the biger hole above knob bezel,shown A. Make the temperature gau

1011Insert sideburner burner into left shelf.shelf, shown A.The stud on bottom of burner fits into rear small hole in sideburner drip pan onSecure bur

1. Do not store or use gasoline or other flammable liquids or vapors in the vicinity of this or any other appliance.2. An LP cylinder not connected fo

*This side UPTank heat shield1312Inside of cart, insert rear shield tab into left slot on upper of lower back panel. Attach front shield tabs under fr

1415Insert hinge pin on bottom of doors into hole in bottom shelf. Press upper hinge pin in front brace, align hinge hole on top of door, and release

1622Install flame tamers by sliding one end of each flame tamer into slots at front of firebox and resting opposite end on pins in back of firebox.Bac

On back of grill, slide grease tray into opening in upper back panel.CAUTIONFailure to install grease tray will cause hot grease to drip from bottom o

–2420LP CYLINDER IS SOLD SEPARATELY. Fill and leak check the cylinder before attaching to grill and regulator (see Use & Care section). Once cylin

EMERGENCIES: If a gas leak cannot be stopped, or a fire occurs due to gas leakage, call the fire department.EmergenciesProblemGas leaking from cracked

Troubleshooting (continued)ProblemBurner(s) will not light using ignitor.(See Electronic Ignition Troubleshooting also)Burner(s) will notmatch light.

Troubleshooting - Electronic IgnitionProblem (Ignition)SECTION INo sparks appear at any electrodes when Electronic Ignition Buttonis pressed; no noise

NOTES28

NOTES29

WARNINGCALIFORNIA PROPOSITION 651. Combustion by-products produced when using this product contain chemicals known to the State of California to cause

NOTES30

Warranty Registration DepartmentP.O. Box 1240Columbus, GA 31902-124031

• NEVER store a spare LP cylinder under or near the appliance or in an enclosed area. • Never fill a cylinder beyond 80% full.• An over filled or impr

WARNINGIf “growing” bubbles appear do not use or move the LP cylinder. Contact an LP gas supplier or your fire department!Connecting Regulator to the

6.Turn the coupling nut clockwise and tighten to a full stop. The regulator will seal on the back-check feature in the LP cylinder valve, resulting in

7WARNINGFor Safe Use of Your Grill and to Avoid Serious Injury:• Do not let children operate or play near grill. • Keep grill area clear and free from

8Burner Flame Check• Remove cooking grates and flame tamers. Light burners, rotate knobs from HI to LOW. You should see a smaller flame in LOW positio

9 Cleaning the Burner AssemblyFollow these instructions to clean and/or replace parts of burnerassembly or if you have trouble igniting grill.1. Tur