Char-Broil 463251413 User's Guide

IMPORTANT: Refer t o the instructions inside when co nv er ti ng th is gr il l to Natural Gas.Assembly instructions © 2013 PRODUCT GUIDEMODEL

This warranty only applies to units purchased from an authorized retailer. Manufacturer warrants to the original consumer-purchaser only that this pr

PARTS LIST NOTE: Some grill parts shown in the assembly steps may differ slightly in appearance from those on your particular grill model. However, th

KKAAANEEERIIIVCCCPGGGTKXBBBOFFFSJJJJWDDDQHHHULLLYMMZPARTS DIAGRAM12

12Bottom shelfNon-lock casterLocking casterRearFrontLeft side panelRight side panelMagnetFrontCaster pinAPlace bottom shelf upside down. Insert Caster

3Left side panelGrill headRight side panelRegulator hoseUpper back panelThis step requires two people to lift and position grill head onto cart. Care

Right side fasciaRight side shelf #10x3/8" screw51/4-20x1 ½" screw1/4-20x1 ½" screwFiber washerFront braceHinge pinControl panel6Attach

7ABCFoldable side shelfFoldable side shelfFoldable side shelfShoulder screw1/4"NutRight side shelfRight side shelfTrackBracketDAttach foldable si

8Insert flange on right side shelf into side shelf brackets on side of firebox, shown A. Attach right side shelf using two 1/4-20x1/2"screws and

Front braceTank heat shieldLeft side panelRight side panelUpper back panelInsert tabs into slots#8x3/8" self-tapping screwNote: Some parts omitte

1211Hinge pin on bottom of doorTop of door#10-24x3/8" screwPRESSInsert hinge pin on bottom of door into hole in bottom shelf. Press upper hinge p

TABLE OF CONTENTS1. Do not store or use gasoline or other flammable liquids or vapors in the vicinity of this or any other appliance.2. An LP cylinder

warming rackCooking grate1314Place cooking grates onto firebox as shown. Insert the three wire ends at rear of warming rack into holes in back of fire

LP CYLINDER IS SOLD SEPARATELY. Fill and leak check the cylinder before attaching to grill and regulator (see Use & Care section). Once cylinder h

22 1Main Burner ConversionYour grill may differ from illustration shown. This portion of the manual covers a variety of grill styles. Use pictures

23 4BezelsValveStemScrewsMain Burner Control KnobsNatural Gas Bezel80007893Pull the Burner Control Knobs off of Valve Stems.Remove Screws and Washe

6Natural Gas Hose Conversion Connection for converting back to LP Tank Gas.Your Grill may differ from illustration shown.LP Regulator Hose AssemblyMan

Connecting Your Grill to the Natural Gas Source.and the socket is recommended, but not required, by the National Fuel Gas Code. Socket connection must

DANGER: If a gas leak cannot be stopped, or a fire occurs due to gas leakage, call the fire department.EmergenciesProblemGas leaking from cracked/cut/

Troubleshooting (continued)ProblemBurner(s) will not light using ignitor.(See Electronic Ignition Troubleshooting also)Burner(s) will notmatch light.

Troubleshooting - Electronic IgnitionProblem (Ignition)SECTION INo sparks appear at any electrodes when Electronic Ignition Buttonis pressed; no noise

NOTES29

WARNINGInstallation Safety Precautions• Use grill, as purchased, only with LP (propane) gas and the regulator/valve assembly supplied. If your grill i

NOTES30

*❶ First Name | Nombre | Prénom Initial | Inicial | Initiale Last Name | Apellido | Nom de Famillie Address (number & street) | Dirección (núm

THANK YOU FOR YOUR RECENT PURCHASE FROM REGISTER YOUR PRODUCT TO RECEIVE A SPECIAL OFFERCHARBROIL.COM/REGISTERCHECK OUT THESEGREAT FEATURESON OUR WEB

• NEVER store a spare LP cylinder under or near the appliance or in an enclosed area. • Never fill a cylinder beyond 80% full.• An over filled or impr

WARNINGIf “growing” bubbles appear do not use or move the LP cylinder. Contact an LP gas supplier or your fire department!Connecting Regulator to the

6.Turn the coupling nut clockwise and tighten to a full stop. The regulator will seal on the back-check feature in the LP cylinder valve, resulting in

7▲▲▲▲▲▲▲▲▲▲▲▲Safety TipsBefore opening LP cylinder valve, check the coupling nut for tightness.When grill is not in use, turn off all control knobs

8Ignitor Check• Turn gas off at LP cylinder. Press and hold electronic ignitor button. "Click" should be heard and spark seen each time bet

9• Clean cooking grates.• Store in dry location.• When LP cylinder is connected to grill, store outdoors in a well-ventilated space and out of reach o