Assembly instructions © 2009 PRODUCT GUIDEMODEL 463250110 © 2009 Char-Broil, LLC Columbus, GA 31902Printed in China Serial NumberDate Purchas
This warranty only applies to units purchased from an authorized retailer. Manufacturer warrants to the original consumer-purchaser only that this pr
PARTS LIST 11NOTE: Some grill parts shown in the assembly steps may differ slightly in appearance from those on your particular grill model. However,
PARTS DIAGRAM12IABCDEFFGHHHHHHHJKLMNOCCCDDDEEEFFFPQRSTAABBGGGCCDDEEEEUVVWXYYZWWXXYYZZBBBKKKAAAHHFFGGIIJJKKLLMMNNNNOOPPQQRRSSTTUUUUUUVVVVPPXXXNNNNJJJII
Right and Left Shelf Assembly1ATowelBarRight Side ShelfCB1/4-20x3/4” Screw7mm Flat WasherAttach two 1/4-20x3/4” screws, 7mm flat washers and 7mmlock w
Sideburner Assembly2 14Position sideburner valve bracket beneath sideburner shelf fascia so that valve stem comes through larger center hole in fasci
315Insert sideburner into left shelf. The stud on bottom of burner fits into rear small hole in sideburner drip pan, shown A.Under sideburner shelf, a
Sideburner Grate 4Place sideburner cooking grate onto sideburner shelf, aligning grate legs with holes in shelf. 16Sideburner Grate Electrode
Trough Install5Place Trough Middle onto firebox, shown A. 17Place Trough A and Trough B onto firebox. Make sure Troughs are put in the right direction
Cooking Grate and Warming Rack6 18Place cooking grates onto the firebox as shown.Place the Warming Rack onto the the firebox.Make sure insert the War
7Condiment Basket AssemblyOpen the door and place the Condiment Basket on the left door inside, make sure insert the legs of the Condiment Basket into
1. Do not store or use gasoline or other flammable liquids or vapors in the vicinity of this or any other appliance.2. An LP cylinder not connected fo
8Electronic Ignition 20Unscrew battery cap on left side panel of cart. Insert AA battery into ignitor, negative (—) end first .Replace battery cap.Bat
LP TankTank Screw at rear of cartCAUTIONLP Tank valve must face to front of cart once tank is attached. Failure to install cylinder correctly may allo
EMERGENCIES: If a gas leak cannot be stopped, or a fire occurs due to gas leakage, call the fire department.EmergenciesProblemGas leaking from cracked
Troubleshooting (continued)ProblemBurner(s) will not light using ignitor.Burner(s) will notmatch light.Sudden drop in gasflow or low flame.Flames blo
Troubleshooting - Integrated Electronic IgnitionProblem (Ignition)SECTION INo sparks appear at any electrodes when burner control knobs are turned to
NOTES25
Warranty Registration DepartmentP.O. Box 1240Columbus, GA 31902-124027
WARNINGCALIFORNIA PROPOSITION 651. Combustion by-products produced when using this product contain chemicals known to the State of California to cause
• NEVER store a spare LP cylinder under or near the appliance or in an enclosed area. • Never fill a cylinder beyond 80% full.• An over filled or impr
WARNINGIf “growing” bubbles appear do not use or move the LP cylinder. Contact an LP gas supplier or your fire department!Connecting Regulator to the
6.Turn the coupling nut clockwise and tighten to a full stop. The regulator will seal on the back-check feature in the LP cylinder valve, resulting in
WARNINGFor Safe Use of Your Grill and to Avoid Serious Injury:• Do not let children operate or play near grill. • Keep grill area clear and free from
Ignitor Check•Turn gas off at LP cylinder. Press and hold electronic ignitor button. "Click" should be heard and spark seen each time betwe
CAUTIONStoring Your Grill•Clean cooking grates.•Store in dry location.•When LP cylinder is connected to grill, store outdoors in a well-ventilated spa
Comments to this Manuals