Char-Broil 463724512 User's Guide

Assembly instructions © 2012 PRODUCT GUIDEMODEL 463724512© 2012 Char-Broil, LLC Columbus, GA 31902Printed in China Serial NumberDate Purchase

Why Clean?We've all heard the saying, 'an ounce of prevention is worth a pound of cure.’ This is great advice when it comes to keeping your

• NEVER store a spare LP cylinder under or near the appliance or in an enclosed area. • Never fill a cylinder beyond 80% full.• An over filled or impr

WARNINGIf “growing” bubbles appear do not use or move the LP cylinder. Contact an LP gas supplier or your fire department!Connecting Regulator to the

6.Turn the coupling nut clockwise and tighten to a full stop. The regulator will seal on the back-check feature in the LP cylinder valve, resulting in

Safety Tips•Before opening LP cylinder valve, check the coupling nut for tightness.When grill is not in use, turn off all control knobs and LP cylinde

Burner Flame Check• Remove cooking grates and flame tamers. Light burners, rotate knobs from HI to LOW. You should see a smaller flame in LOW position

Cleaning the Burner AssemblyFollow these instructions to clean and/or replace parts of burnerassembly or if you have trouble igniting grill.1. Turn g

This warranty only applies to units purchased from an authorized retailer. Manufacturer warrants to the original consumer-purchaser only that this pr

Key Qty DescriptionA 1 TOP LID, GASB 8 RUBBER BUMPER, F/ TOP LIDC 2 LOGO PLATED 2 TEMPERATURE GAUGEE 2 BEZEL, F/ TEMPERATURE GAUGEF 2 LID HANDLEG 4 BE

Exploded ViewPage 19BJLLLCDGHFPMONCJJJIEDGBBSSHFRPPNNMMMQQKEEMMCCDDFFHHLLEGGJJXVWUIIIRRFFFEEEKKYHHHYYVVUUUUWWZZBBBCCCGGGTTAAADDDVVXXAOOMMMSTZQLIIKKKAA

1. Do not store or use gasoline or other flammable liquids or vapors in the vicinity of this or any other appliance.2. An LP cylinder not connected fo

ASSEMBLY STEPS1/4-20x1/2” Machine screwQty. 4 1/4-20x2-1/2” Machine screwQty. 4Page 20Caster Bracket Assembly to LegsA Attach (1) caster bracket asse

1/4-20x2-1/2” Machine screwQty. 41/4-20Flanged Hex NutQty. 4Page 21Bottom Shelf to LegsA Attach bottom shelf to left and right leg assemblies with (4

Page 22Rear Panel, Door Frame BracketA Attach rear panel to back of cart with (4) #10-24x3/8" screws.B Attach door frame bracket to front of car

Page 23Bottom Shelf FasciaA Attach bottom shelf fascia with (2) #10x3/8" self-tap screws, aligning door hinge hole with the door hinge holes on

Page 24Grill body assembly to cartA This step requires two people to lift and position the grill body onto the cart. Make sure the regulator hose rema

1/4-20x1/2” Machine screwQty. 4 #10x3/8” Self-tap screw,Qty. 3Page 25Right Side Fascia & Side HandleA Attach right side fascia to side shelf with

1/4-20x1/2” Machine screwQty. 4 Page 26Sideburner FasciaA Attach sideburner fascia to sideburner shelf with (3) #10x3/8” self-tap screws.B Tighten s

1/4-20x1/2” Machine screw,qty. 21/4" Flat washerQty. 2 Page 27Ignitor Wire, Side Burner Clip, Side Burner Grate, and Control KnobA Attach side b

Page 28Warming Rack, Cooking Grate, CrankA Install warning rack by inserting legs into the holes in the sides of the firebox.B Place cooking grates

Page 29Gas Grill Grease tray, Charcoal Grill Ash PanA Slide grease tray into the track beneath the GAS side firebox.B Slide charcoal pan into the tr

WARNINGCALIFORNIA PROPOSITION 651. Combustion by-products produced when using this product contain chemicals known to the State of California to cause

EMERGENCIES: If a gas leak cannot be stopped, or a fire occurs due to gas leakage, call the fire department.EmergenciesProblemGas leaking from cracked

Troubleshooting (continued)ProblemBurner(s) will not light using ignitor.(See Electronic Ignition Troubleshooting also)Burner(s) will notmatch light.

Troubleshooting - Electronic IgnitionProblem (Ignition)SECTION INo sparks appear at any electrodes when Electronic Ignition Buttonis pressed; no noise

NOTESPage 33

NOTESPage 34

*❶ First Name | Nombre | Prénom Initial | Inicial | Initiale Last Name | Apellido | Nom de FamillieAddress (number & street) | Dirección (número y

GRILL MAINTENANCEFrequency of clean up is determined by how often the grill is used. Make sure coals are completely extinguished before cleaning insi

THE HEAT OF THE COALSseconds you can hold the palm of your hand 4 inches above the coals temperature range (Fº) visual cuesHOT COALS 2 400 to 450 bare

Direct and Indirect GrillingDirect Grilling - For most grilling, the ignited coals are spread in a single layer under the food. This is called direct

First Time UseRead your Assembly Manual and ensure the grill is put together properly. Remove all Point-of-Purchase advertising material from all gri

Outdoor grilling is really quite simple. You'll succeed with burgers, dogs, or steaks usually on your very first try. With experience, you will

Cooking on your new grill is a hands-on experience, and it is recommended to remain outside with your grill while cooking. Grilling can be affected b