Char-Broil 463411911 User's Guide

Assembly instructions © 2010PRODUCT GUIDEMODEL 463411911© 2010 Char-Broil, LLC Columbus, GA 31902Printed in China Serial NumberDate PurchasedIMPO

6.Turn the coupling nut clockwise and tighten to a full stop. The regulator will seal on the back-check feature in the LP cylinder valve, resulting in

WARNINGFor Safe Use of Your Grill and to Avoid Serious Injury:• Do not let children operate or play near grill. • Keep grill area clear and free from

Burner Flame Check• Remove cooking grates and flame tamers. Light burners, rotate knobs from HI to LOW. You should see a smaller flame in LOW position

Cleaning the Burner AssemblyFollow these instructions to clean and/or replace parts of burnerassembly or if you have trouble igniting grill.1. Turn g

This warranty only applies to units purchased from an authorized retailer. Manufacturer warrants to the original consumer-purchaser only that this pr

PARTS LIST15 NOTE: Some grill parts shown in the assembly steps may differ slightly in appearance fromthose on your particular grill model. However,

ABCCDEFGHHIJJKKLMNOPQRSTUWWVXYZZZZAACCDDEEFFGGHHIIJJJJKKKKKKKKKKLLMMNNOOPPQQRRSSTTUUVVWWXXYYZZBBBCCCBBWPARTS DIAGRAM16VWAAAAAAZZ

ASSEMBLY17 1Bottom Shelf and Legs □ Attach legs to bottom shelf with 1/4-20x2-3/8” machine screws. Be sure that metal tabs on legs face to c

183Side Braces □ Turn cart upright.□ Attach side braces to legs using four 1/4-20x1/2” screws each side.Machine ScrewsQty. 81/4-20x1/2”4Front

19 5Tank Exclusion Brace 46Back BraceMachine ScrewsQty. 15/32-32x3/8”Machine ScrewsQty. 25/32-32x3/8”Back BraceTank ExclusionBrace□ Insert th

1. Do not store or use gasoline or other flammable liquids or vapors in the vicinity of this or any other appliance.2. An LP cylinder not connected fo

Tank Heat Shield20 7 Tank Heat Shield 48 Grill Head Machine ScrewsQty. 45/32-32x3/8”Machine ScrewsQty. 61/4-20x1/2”ABC□ Use four -32x

21 9Side Shelf and Fascias Machine ScrewsQty. 65/32-32x3/8”□ Use three -32x3/8” machine screws to attach fascia to left side shelf as shown

AB22 10 Left Side Shelf □ Loosen the preassembled screws in the left rear leg and front of firebox, shown A, to within 1/8" of surfac

AB23 11 SideBurner Shelf Machine ScrewsQty. 21/4-20x1/2”□ Loosen the preassembled screws in the right rear leg and front of firebox, shown

Sideburner TubeSideburner ValveBSideburner BezelA24 12 Side Burner Valve and Bezel Machine ScrewsQty. 25/32-32x3/8”□ Remove the two screws,

Sideburner Knob25 13 Sideburner Knob □ Push knob onto valve stem.414 Side Burner Ignitor Wire Sideburner Electrode WireIgnitor Wire

Heat DiffuserGrease TrayGrease Pan26 15 Grease Tray and Grease Pan □ Slide grease tray onto rails beneath firebox past rail stops. Slide

Warming RackCooking Grate+_AAA Battery17 Install Grates, Warming Rack and Battery 418□ LP tank is sold separately. Use only with an OPD (over

EMERGENCIES: If a gas leak cannot be stopped, or a fire occurs due to gas leakage, call the fire department.EmergenciesProblemGas leaking from cracked

Troubleshooting (continued)ProblemBurner(s) will not light using ignitor.(See Electronic Ignition Troubleshooting also)Burner(s) will notmatch light.

WARNINGCALIFORNIA PROPOSITION 651. Combustion by-products produced when using this product contain chemicals known to the State of California to cause

Troubleshooting - Electronic IgnitionProblem (Ignition)SECTION INo sparks appear at any electrodes when Electronic Ignition Buttonis pressed; no noise

31 Warranty Registration DepartmentP.O. Box 1240Columbus, GA 31902-1240

First Time UseRead your Assembly Manual and ensure the grill is put together properly. Remove all Point-of-Purchase advertising material from all gri

Outdoor grilling is really quite simple. You'll succeed with burgers, dogs, or steaks usually on your very first try. With experience, you will

USDA Recommended Safe MinimumInternal TemperaturesBeef, Veal, Lamb, Steaks, & Roasts 145° FFish 145° FPork 160° FBeef, Veal, Lamb Ground 160° FEgg

Why Clean?We've all heard the saying, “an ounce of prevention is worth a pound of cure.” This is great advice when it comes to keeping your gril

• NEVER store a spare LP cylinder under or near the appliance or in an enclosed area. • Never fill a cylinder beyond 80% full.• An over filled or impr

WARNINGIf “growing” bubbles appear do not use or move the LP cylinder. Contact an LP gas supplier or your fire department!Connecting Regulator to the