Char-Broil 463621611 User's Guide

Assembly instructions © 2010 PRODUCT GUIDEMODEL 463621611 © 2010 Char-Broil, LLC Columbus, GA 31902Printed in China Serial NumberDate Purcha

6.Turn the coupling nut clockwise and tighten to a full stop. The regulator will seal on the back-check feature in the LP cylinder valve, resulting in

11WARNINGFor Safe Use of Your Grill and to Avoid Serious Injury:• Do not let children operate or play near grill. • Keep grill area clear and free f

12Burner Flame Check• Remove cooking grates and flame tamers. Light burners, rotate knobs from HI to LOW. You should see a smaller flame in LOW positi

13Cleaning the Burner AssemblyFollow these instructions to clean and/or replace parts of burnerassembly or if you have trouble igniting grill.1. Turn

This warranty only applies to units purchased from an authorized retailer. Manufacturer warrants to the original consumer-purchaser only that this pr

PARTS LIST15Key Qty DescriptionA 1 FIREBOXB 1 LIDC 1 LOGO PLATED 1 HOSE VALVE REGULATOR ASSEMBLYE 1 CONTROL PANELF 2 BURNERG 1 CARRYOVER TUBEH 1 ELECT

PARTS DIAGRAM 16BADCJRUMGFILKQSIITEOPHHVYHNWXAAZEECCJJFFDDFIJKTTVBBGG

ASSEMBLY1217Hitch PinQty. 1Wheel BushingQty. 1“Cone” side of wheel against legInsert the front and rear leg assemblies into tank support bracket and l

3418Tank exclusion wire Hook tank exclusion wire onto back brace, then flex the tank exclusion wire to insert the other end into the hole on front

5619Firebox assembly Lift and carefully position firebox assembly onto cart assembly, make sure the legs on firebox are aligned with the posts of

1. Do not store or use gasoline or other flammable liquids or vapors in the vicinity of this or any other appliance.2. An LP cylinder not connected fo

78 20Hitch PinQty. 2Hinge PinQty. 2Lid assembly Place lid assembly onto firebox, align hinges. Hinges on lid fit inside hinges on firebox. Secur

91021Cooking Grate Place cooking grate into firebox.Cooking GrateSwing Away Insert ends of swing away pivot wire into holes in sides of grill

111222 Failure to install grease cup clip and cup will cause hot grease to drip from bottom of grill with risk of fire or property damage.CAUTIONGr

13Tank collar opening must face to front of grill. Set bottom of tank into notches of tank bracket. .Lean tank inward andengage tank collar with tan

EMERGENCIES: If a gas leak cannot be stopped, or a fire occurs due to gas leakage, call the fire department.EmergenciesProblemGas leaking from cracked

Troubleshooting (continued)ProblemBurner(s) will not light using ignitor.Burner(s) will notmatch light.Low flame, drop in gas flow.Flames blow out.Fl

NOTES26

Warranty Registration DepartmentP.O. Box 1240Columbus, GA 31902-124027

WARNINGCALIFORNIA PROPOSITION 651. Combustion by-products produced when using this product contain chemicals known to the State of California to cause

First Time UseRead your Assembly Manual and ensure the grill is put together properly. Remove all Point-of-Purchase advertising material from all gri

Outdoor grilling is really quite simple. You'll succeed with burgers, dogs, or steaks usually on your very first try. With experience, you will

USDA Recommended Safe MinimumInternal TemperaturesBeef, Veal, Lamb, Steaks, & Roasts 145° FFish 145° FPork 160° FBeef, Veal, Lamb Ground 160° FEgg

Why Clean?We've all heard the saying, 'an ounce of prevention is worth a pound of cure.’ This is great advice when it comes to keeping your

• NEVER store a spare LP cylinder under or near the appliance or in an enclosed area. • Never fill a cylinder beyond 80% full.• An over filled or impr

WARNINGIf “growing” bubbles appear do not use or move the LP cylinder. Contact an LP gas supplier or your fire department!Connecting Regulator to the