Char-Broil 463230710 User's Guide

Assembly instructions © 2009 PRODUCT GUIDEMODEL 463230710 © 2009 Char-Broil, LLC Columbus, GA 31902Printed in China Serial NumberDate Purcha

6.Turn the coupling nut clockwise and tighten to a full stop. The regulator will seal on the back-check feature in the LP cylinder valve, resulting in

WARNINGFor Safe Use of Your Grill and to Avoid Serious Injury:• Do not let children operate or play near grill. • Keep grill area clear and free from

Burner Flame Check• Remove cooking grates and flame tamers. Light burners, rotate knobs from HI to LOW. You should see a smaller flame in LOW position

Cleaning the Burner AssemblyFollow these instructions to clean and/or replace parts of burnerassembly or if you have trouble igniting grill.1. Turn g

This warranty only applies to units purchased from an authorized retailer. Manufacturer warrants to the original consumer-purchaser only that this pr

PARTS LISTKey Qty DescriptionA 1 FIREBOXB 5 MAIN BURNER-TUBE BURNERC 1 MAIN BURNER-BAR BURNERD 1 ELECTRODE, F/ TUBE BURNERE 1 ELECTRODE, F/ BAR BURNER

PARTS DIAGRAMWVNCCBCDEBBBBPOTSQRIHIIJJAGGGHHMTTNNKBBEEAAZYXFFUFFFFDDLLLLLLMMMMMRRKKYYPPVVWWMMXXZZLLLMQQOOAAASSJBBBBBBZZWWTTRRKKKKKKKKWWWVVVVUUCCC16

1/4 -20x2-3/8"Machine Screw"Qty. 6ASSEMBLY1• Place bottom shelf between side panels . Attach to left and right side panels with (4) 1/4”-20

3• Hook tank exclusion wire onto the metal taps on lower back panel, attach other ends to bottom shelf with #8-32x3/8” sheet metal screws.4• Attach to

5•• Attach the two fixed casters to left leg and the two locking casters to right leg. Use the provided caster wrench to fully tighten casters.Tu

1. Do not store or use gasoline or other flammable liquids or vapors in the vicinity of this or any other appliance.2. An LP cylinder not connected fo

6• Stand cart upright. • This step requires two people to lift and position grill head onto cart.• Carefully lower the grill head onto the cart. Make

7mm Flat WasherQty. 27• Attach towel bar to right side shelf with 1/4-20x1/2” Screws , 7mm lock washers and 7mm flat washers (A). • Hook side wall of

9101/4-20x1/2"Machine ScrewQty. 41/4 -20Flange Nut"Qty: 4sheet metal screwsQty. 3#8-32x3/8" • Hook side wall of sideburner shelf over s

11M4 Wing NutQty. 1#8-32X3/8” SS ScrewQty. 2• Attach sideburner bezel and valve with #8-32x3/8” SS screws. (A). • Place sideburner into shelf. Make su

12#10-24x1/2"Machine ScrewQty: 45mm Flat WasherQty: 45mm Lock WasherQty: 4• Attach handle to door with #10-24x1/2” machine screws, 5mm flat washe

• Place heat tents over tube burners by inserting tabs into slots in front of firebox. Opposite ends of heat tents rest on pins in back of firebox.

Grease TrayGrease Pan1516• (over-fill protection device)to grill and regulator. • Place Lp tank into hole in bottom shelf with tank collar opening fac

EMERGENCIES: If a gas leak cannot be stopped, or a fire occurs due to gas leakage, call the fire department.EmergenciesProblemGas leaking from cracked

Troubleshooting (continued)ProblemBurner(s) will not light using ignitor.(See Electronic Ignition Troubleshooting also)Burner(s) will notmatch light.

Troubleshooting - Electronic IgnitionProblem (Ignition)SECTION INo sparks appear at any electrodes when Electronic Ignition Buttonis pressed; no noise

WARNINGCALIFORNIA PROPOSITION 651. Combustion by-products produced when using this product contain chemicals known to the State of California to cause

NOTES30

Warranty Registration DepartmentP.O. Box 1240Columbus, GA 31902-124031

First Time UseRead your Assembly Manual and ensure the grill is put together properly. Remove all Point-of-Purchase advertising material from all gri

Outdoor grilling is really quite simple. You'll succeed with burgers, dogs, or steaks usually on your very first try. With experience, you will

USDA Recommended Safe MinimumInternal TemperaturesBeef, Veal, Lamb, Steaks, & Roasts 145° FFish 145° FPork 160° FBeef, Veal, Lamb Ground 160° FEgg

Why Clean?We've all heard the saying, “an ounce of prevention is worth a pound of cure.” This is great advice when it comes to keeping your gril

• NEVER store a spare LP cylinder under or near the appliance or in an enclosed area. • Never fill a cylinder beyond 80% full.• An over filled or impr

WARNINGIf “growing” bubbles appear do not use or move the LP cylinder. Contact an LP gas supplier or your fire department!Connecting Regulator to the