Char-Broil 463224611 User's Guide

PRODUCT GUIDEMODEL 463224611Sears Item No. 16138Sears Model No. 415.16138110Serial NumberDate PurchasedIMPORTANT: Fill out the product record informa

This warranty only applies to units purchased from an authorized retailer. Manufacturer warrants to the original consumer-purchaser only that this pr

PARTS LISTNOTE: Some grill parts shown in the assembly steps may differ slightly in appearance from those on your particular grill model. However, the

PARTS DIAGRAM12AIBFJAAKVTULYYOWQRSYYMNUUPWWEEHHIINNDDFFBBCCGGJJXXKKQQVVPPLLRRSSSSTTXGHEDDCCOOMMZZ

21/4-20x1/2” screw1Attach side panels to bottom shelf using three 1/4-20x1/2” screws, 7mm lock washers, and 7mm flat washers per panel.IMPORTANT: Pane

34This step requires two people to lift and position grill head onto cart. Carefully lower the grillhead onto the cart, aligning slots at bottom of gr

On back of grill, place upper back panel between side panels and above lower back panel. Do not fully tighten screws until side shelf installation is

166Fascia, right side shelfBracketInsert flange on right side shelf into side shelf brackets on side of firebox. Attach rear of shelf using one 1/4-20

177Now you may fully tighten lower screws on upper back panel.1/4-20x3/4”screwBack of main control panelControl panelFascia, left sideburner shelf

98First, remove the two screws and lock washers factory attached to the sideburner valve bracket. Position sideburner valve bracket beneath sideburner

1119Under sideburner shelf, attach sideburner ignitor wire to electrode, shown A. Place sideburner grate onto sideburner shelf,aligning grate legs wit

1. Do not store or use gasoline or other flammable liquids or vapors in the vicinity of this or any other appliance.2. An LP cylinder not connected fo

*This side UPTank heat shield13Inside of cart, insert rear shield into left slot(#1) on top of lower back panel. Insert left grease tray rail into slo

1521Wire12345(a)(b)ignition moduleElectronicRight side panelBANutConnect each of the wires from the main burner electrodes, and sideburner electrode i

17 22Assembledwarming rackPlace cooking grates onto the firebox as shown. Insert the two wire ends at rear of warming rack into holes in back of fire

2318On back of grill, slide grease tray into opening in upper back panel.CAUTIONFailure to install grease tray will cause hot grease to drip from bott

19LP CYLINDER IS SOLD SEPARATELY. Fill and leak check the cylinder before attaching to grill and regulator (see Use & Care section). Once cylinder

EMERGENCIES: If a gas leak cannot be stopped, or a fire occurs due to gas leakage, call the fire department.EmergenciesProblemGas leaking from cracked

Troubleshooting (continued)ProblemBurner(s) will not light using ignitor.(See Electronic Ignition Troubleshooting also)Burner(s) will notmatch light.

Troubleshooting - Electronic IgnitionProblem (Ignition)SECTION INo sparks appear at any electrodes when Electronic Ignition Buttonis pressed; no noise

NOTES3 42228

NOTES29 29

WARNINGCALIFORNIA PROPOSITION 651. Combustion by-products produced when using this product contain chemicals known to the State of California to cause

NOTES3 430

31 Warranty Registration DepartmentP.O. Box 1240Columbus, GA 31902-1240

• NEVER store a spare LP cylinder under or near the appliance or in an enclosed area. • Never fill a cylinder beyond 80% full.• An over filled or impr

WARNINGIf “growing” bubbles appear do not use or move the LP cylinder. Contact an LP gas supplier or your fire department!Connecting Regulator to the

6.Turn the coupling nut clockwise and tighten to a full stop. The regulator will seal on the back-check feature in the LP cylinder valve, resulting in

WARNINGFor Safe Use of Your Grill and to Avoid Serious Injury:• Do not let children operate or play near grill. • Keep grill area clear and free from

Burner Flame Check• Remove cooking grates and flame tamers. Light burners, rotate knobs from HI to LOW. You should see a smaller flame in LOW position

Cleaning the Burner AssemblyFollow these instructions to clean and/or replace parts of burnerassembly or if you have trouble igniting grill.1. Turn g