Char-broil 463741008 User Manual

THIS GRILL IS FOR OUTDOOR USE ONLY.If you have any questions or need assistance during assembly, please call 1-800-241-7548.To insure your satisfactio

Food SafetyFood safety is a very important part of enjoying the outdoor cooking experience. To keep food safe from harmful bacteria, follow these four

463741008 • 11Certified Grill Parts And Accessories®, Char-Broil and Design®, Char-Broil (Gas Grill Briquettes)®, Char-Diamonds®, Cooking Zone and D

PARTS DIAGRAM – Model No. 46374100812 • 463741008NOTE: Some grill parts shown in the assembly steps may differ slightly in appearance from those on

463741008 • 13ASSEMBLY – Model No. 463741008ALeft legno leg extendersLeg ShelfSupportBSupport Bar21(A) Place leg shelf support onto leg with leg ext

14 • 46374100834Right leg, place support bar between legs, and place two rails on outside of leg. Attach with #10-24x1-3/4" machine screws and

463741008 • 1556(A) Place hole in lower panel on top, attach to front of cart with #10-24x1/2" machine screws in lower holes and with push fas

16 • 4637410087(A) Attach control panel to cart with #10-24x1-3/4" machine screws and #10-24 wing nuts.(B) Place valve/hose/regulator onto con

463741008 • 178(A) P osition heat shield as shown. Attach with #10-24x1-1/4" carriage bolt, fiber washers and #10-24 wing nut. (B) Place burne

10Attach lower lid hinges to back of firebox using #10-24x1/2” machine screws, fiber washer, and #10-24 flange nuts. The center flat portion of the hi

1” Hitch PinQty. 2Hinge PinQty. 212Place lid assembly onto firebox, aligning hinges. Hinges on lid fit inside hinges on firebox. Secure using two hing

2 • 4637410081. Do not store or use gasoline or other flammable liquids or vapors in the vicinity of this or any other appliance.2. An LP cylinder n

Leg WireSwing Away PivotWire14Insert ends of Swing Away pivot wire into holes in sides of grill lid. Insert ends of Swing Away leg wire into holes in

16Insert tank wire into left legs. Rotate tank wire inward toward cart.17Tank collar opening must face to front of grill (A). Set bottom of tank into

EMERGENCIES: If a gas leak cannot be stopped, or a fire occurs due to gas leakage, call the fire department.EmergenciesProblemGas leaking from cracked

Troubleshooting (continued)ProblemBurner(s) will not light using ignitor.Burner(s) will notmatch light.Low flame, drop in gas flow.Flames blow out.Fl

Manufacturer warrants to the original consumer-purchaser only that this product shall be free from defects in workmanship and materials after correct

Page intentionally blank463741008 • 25

Please register your grill online at:(If you register online, you do not need to send in this registration card.)WWW.GRILLREGISTRATION.COMChimenea/ En

Char-Broil, LLC Printed in China • Columbus, GA 31902 • STOPShould you encounter a problem with our productCALL US FIRSTDo not return this product to

TABLE OF CONTENTSFor Your Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2Grill Service Center. . . . . . . . . .

4 • 463741008• NEVER store a spare LP cylinder under or near the appliance or in an enclosed area. • Never fill a cylinder beyond 80% full.• An over

WARNINGIf “growing” bubbles appear do not use or move the LP cylinder. Contact an LP gas supplier or your fire department!Connecting Regulator to the

6. Turn the coupling nut clockwise and tighten to a full stop. The regulator will seal on the back-check feature in the LP cylinder valve, resulting i

For Safe Use of Your Grill and to Avoid Serious Injury:• Do not let children operate or play near grill. • Keep grill area clear and free from materia

8 • 463741008Burner Flame Check• Remove cooking grates and flame tamers. Light burners, rotate knobs from HI to LO. You should see a smaller flame i

Cleaning the Burner AssemblyFollow these instructions to clean and/or replace parts of burnerassembly or if you have trouble igniting grill.1. Turn g