Char-Broil 463273513 User's Guide

Assembly instructions © 2013 PRODUCT GUIDEMODEL 463273513© 2013 Char-Broil, LLC Columbus, GA 31902Printed in China Serial NumberDate Purchas

3. Remove carryover tubes and burners.4.5. Carefully lift each burner up and away from valve openings.We suggest three ways to clean the burner tubes.

This warranty only applies to units purchased from an authorized retailer. Manufacturer warrants to the original consumer-purchaser only that this pr

PARTS LISTNOTE: Some grill parts shown in the assembly steps may differ slightly in appearance from those on your particular grill model. However, the

PARTS DIAGRAMAIBBVWJJJKKSSBBBYYAAAKLXXLLMMOOMTNUSOPPQQORIIRROOUUTTUUTTTTTTBCEGHFXQQZZRRRRDDYZZYAADDCNNPPWW13FFCCEEGGHHVV

ASSEMBLY12 14Left side panel(with large hole)Right side panelMagnetFrontBottom shelfRearFrontAPlace bottom shelf upside down. Insert Caster Pin into

3ALower back panel1/4-20x1/2" screw15 Grill headRegulator hoseVertical flangePlace lower back panel between side panels at rear of bottom shelf.

Upper back panel651/4-20x1 ½" screw Knob Temperature gauge Temperature gauge stem Control panelCBBack of the panelOn back of grill, place upper

7 17 C1/4" nut1/4" nutBracketRight side selfvalve stembezel (blank)Knob#8-32x3/8" screwGAInsert flange on right side shelf into side s

18 8Left sideburner shelfFlange into bracketBracket1/4-20x1/2" screwControl panel#8x3/8" self-tapping screwBack of main control panellarg

19109Control knob bezelInstall bezel with OFF at topScrews and Washers removed from valve bracketValve stem#8-32x3/8" screwValve stemSideburner b

TABLE OF CONTENTS1. Do not store or use gasoline or other flammable liquids or vapors in the vicinity of this or any other appliance.2. An LP cylinder

8a112012Front braceInsert front brace under control panel and between cart panels. Make sure door hinge pin is on the top side and facing the front. S

13AFront braceFront braceHeat shieldTank wireTank wireLeft grease tray railRight grease tray railRails#8x3/8" self-tapping#8x3/8" self-tappi

BATank exclusion wire shelfLeft side panelInside of cart, insert tank exclusion wire shelf ends into lower back panel, shown A. Attach front left side

1516 23+-Electronic ignition moduleNutCapAA batteryRight side panelBCA21Wires34(a)5(b)Inside of cart, connect each of the wires from main burner elec

1817Flame tamerPinTop of doorHinge pin on bottom of doorPRESSRight doorLeft doorDoor handle#10-24x3/8" screwFront braceAttach door handle to left

19IR cooking gratePlace IR cooking grates onto the firebox as shown. Insert the two wire ends at rear of warming rack into holes in back of firebox. Fro

21On back of grill, slide grease tray into opening in upper back panel.CAUTIONFailure to install grease tray will cause hot grease to drip from bottom

DANGER: If a gas leak cannot be stopped, or a fire occurs due to gas leakage, call the fire department.EmergenciesProblemGas leaking from cracked/cut/

Troubleshooting (continued)ProblemBurner(s) will not light using ignitor.(See Electronic Ignition Troubleshooting also)Burner(s) will notmatch light.

Troubleshooting - Electronic IgnitionProblem (Ignition)SECTION INo sparks appear at any electrodes when Electronic Ignition Buttonis pressed; no noise

WARNINGInstallation Safety Precautions• Use grill, as purchased, only with LP (propane) gas and the regulator/valve assembly supplied. If your grill i

30NOTES

*❶ First Name | Nombre | Prénom Initial | Inicial | Initiale Last Name | Apellido | Nom de Famillie Address (number & street) | Dirección (núm

THANK YOU FOR YOUR RECENT PURCHASE FROM REGISTER YOUR PRODUCT TO RECEIVE A SPECIAL OFFERCHARBROIL.COM/REGISTERCHECK OUT THESEGREAT FEATURESON OUR WEB

• NEVER store a spare LP cylinder under or near the appliance or in an enclosed area. • Never fill a cylinder beyond 80% full.• An over filled or impr

WARNINGIf “growing” bubbles appear do not use or move the LP cylinder. Contact an LP gas supplier or your fire department!Connecting Regulator to the

6.Turn the coupling nut clockwise and tighten to a full stop. The regulator will seal on the back-check feature in the LP cylinder valve, resulting in

7▲▲▲▲▲▲▲▲▲▲▲▲WARNINGFor Safe Use of Your Grill and to Avoid Serious Injury:• Do not let children operate or play near grill. • Keep grill area clear

8•••••••Burner Flame Check•Remove cooking grates and flame tamers. Light burners, rotate knobs from HIGH to LOW. You should see a smaller flame in LOW

9CAUTIONStoring Your Grill• Clean cooking grates.• Store in dry location.• When LP cylinder is connected to grill, store outdoors in a well-ventila