Char-broil 463210510 User Manual

Assembly instructions © 2009 PRODUCT GUIDEMODEL 463210510 © 2009 Char-Broil, LLC Columbus, GA 31902Printed in China Serial NumberDate Purcha

6.Turn the coupling nut clockwise and tighten to a full stop. The regulator will seal on the back-check feature in the LP cylinder valve, resulting in

WARNINGFor Safe Use of Your Grill and to Avoid Serious Injury:• Do not let children operate or play near grill. • Keep grill area clear and free from

Burner Flame Check• Remove cooking grates and flame tamers. Light burners, rotate knobs from HI to LOW. You should see a smaller flame in LOW position

Cleaning the Burner AssemblyFollow these instructions to clean and/or replace parts of burnerassembly or if you have trouble igniting grill.1. Turn g

This warranty only applies to units purchased from an authorized retailer. Manufacturer warrants to the original consumer-purchaser only that this pr

NOTE: Some grill parts shown in the assembly steps may differ slightly in appearance fromthose on your particular grill model. However, the methood of

PARTS DIAGRAM16ABBCDEFFGKLMNOPQQRSTUVVVWWWXYAAZBBDDEEFFCCGGHHIIJJDDDLLMMNNOOPPQQQQRRSSTTUUVVWWXXYYZZAAABBBCCCEEEKKOHIJ

ASSEMBLYPlace legs as shown.NOTE:Left leg assembly has large holes on ends of legs. Attach center brace, left front and left rearleg with 1/4-20x1/2&q

ASSEMBLYAttach upper and lower front panel to cart with 1/4-20x1/2" screws, 7mm Flat Washer and 7mm Lock Washer on each side.Turn assembly upsi

Attach cylinder insulation board to cart back brace with #10-24x1/2" screws. Place grease tray to the cart assembly as shown.Insert tank retainer

1. Do not store or use gasoline or other flammable liquids or vapors in the vicinity of this or any other appliance.2. An LP cylinder not connected fo

ASSEMBLYPlace right side shelf to the side of firebox(B).Tighten the pre-installed screws to the right side shelf(C).78This step requires two people

ASSEMBLYAttach right side shelf to the firebox with 1/4-20x1/2" screws on the upper holes. Attach right towel bar to the rear of right side shelf

Remove two #8-32x5/16” screws from sideburner valve bracket,set aside until step 12.Repeat step 8(A)on left side shelf. Place left side shelf to the

Attach bezel to valve with two #8-32x5/16” screws which was removed previously from sideburner valve bracket.Be sure valve is connected with side burn

Place cooking grates onto grate rests. Unscrew ignitor cap and place AA battery into ignitor slot with positive end (+) facing outward. Screw ignitor

Grease Cup ClipGrease CupCAUTION• Failure to install tank correctly may allow gas hose to be damaged in operation, resulting in the risk of fire.See U

EMERGENCIES: If a gas leak cannot be stopped, or a fire occurs due to gas leakage, call the fire department.EmergenciesProblemGas leaking from cracked

Troubleshooting (continued)ProblemBurner(s) will not light using ignitor.(See Electronic Ignition Troubleshooting also)Burner(s) will notmatch light.

Troubleshooting - Electronic IgnitionProblem (Ignition)SECTION INo sparks appear at any electrodes when Electronic Ignition Buttonis pressed; no noise

NOTES29

WARNINGCALIFORNIA PROPOSITION 651. Combustion by-products produced when using this product contain chemicals known to the State of California to cause

NOTES30

Warranty Registration DepartmentP.O. Box 1240Columbus, GA 31902-124031

First Time UseRead your Assembly Manual and ensure the grill is put together properly. Remove all Point-of-Purchase advertising material from all gri

Outdoor grilling is really quite simple. You'll succeed with burgers, dogs, or steaks usually on your very first try. With experience, you will

USDA Recommended Safe MinimumInternal TemperaturesBeef, Veal, Lamb, Steaks, & Roasts 145° FFish 145° FPork 160° FBeef, Veal, Lamb Ground 160° FEgg

Why Clean?We've all heard the saying, “an ounce of prevention is worth a pound of cure.” This is great advice when it comes to keeping your gril

• NEVER store a spare LP cylinder under or near the appliance or in an enclosed area. • Never fill a cylinder beyond 80% full.• An over filled or impr

WARNINGIf “growing” bubbles appear do not use or move the LP cylinder. Contact an LP gas supplier or your fire department!Connecting Regulator to the