PRODUCT GUIDEMODEL 463263110Serial NumberDate PurchasedIMPORTANT: Fill out the product record information below.See rating label on grill for serial
3. Remove carryover tubes and burners.4.5. Carefully lift each burner up and away from valve openings.We suggest three ways to clean the burner tubes.
This warranty only applies to units purchased from an authorized retailer. Manufacturer warrants to the original consumer-purchaser only that this pr
PARTS LISTNOTE: Some grill parts shown in the assembly steps may differ slightly in appearance from those on your particular grill model. However, the
PARTS DIAGRAM13QQABCCDDEFGHIJKLMAABBDDAAAYBBBDDDCCCJJKKLLMMNOPQRSTUVWYZZNNOOPPRRSSTTUUVVWWYYZZXSSFFFFUUUUUUVVVVVVWWIIEEGGCCHHXX
ASSEMBLY21/4-20x1/2” screw1Attach side panels to bottom shelf using three 1/4-20x1/2” screws, 7mm lock washers, and 7mm flat washers per panel.IMPORTA
34Place lower back panel between side panels at rear of bottom shelf. Make sure the slots are positioned as shown (A). Secure lower back panel to side
Upper back panel651/4-20x1½”screw7mm lockwasher7mm flatwasher 16On back of grill, place upper back panel between side panels and above lower back pan
7 17Insert flange on right side shelf into side shelf brackets on side of firebox, shown A. Attach rear of shelf using one 1/4-20x3/4” screw, 7mm loc
818Now you may fully tighten lower screws on upper back panel.1/4-20x3/4”screwBack of main control panelControl panelFascia, left sideburner shelfLeft
9Insert front brace under control panel and between cart side panels. Make sure door hinge pins are on the top side and facing the front. Secure using
1. Do not store or use gasoline or other flammable liquids or vapors in the vicinity of this or any other appliance.2. An LP cylinder not connected fo
Insert sideburner burner into left shelf.shelf, shown A.The stud on bottom of burner fits into rear small hole in sideburner drip pan onSecure burner
12A 21Inside of cart, insert heat shield rear tabs(without holes) into slots between upper and lower back panels. Then insertleft and right grease tr
13Inside of cart, insert tank exclusion wire shelf ends into lower back panel, shown A. Attach front left side of wire shelf to the left side panel wi
1415 23Release the cap and nut from electronic ignition module. Attach electronic ignition module and heat shield to the cart rightback of the electr
172416Install flame tamers by sliding one end of each flame tamer into slots at front of firebox and resting opposite end on pins in back of firebox.F
1925On back of right side fascia, open battery box by sliding its cover. Put two AA batteries in the box and then replace the cover.18Battery boxAA ba
2021 LP CYLINDER IS SOLD SEPARATELY. Fill and leak check the cylinder before attaching to grill and regulator (see Use & Care section). Once cylin
EMERGENCIES: If a gas leak cannot be stopped, or a fire occurs due to gas leakage, call the fire department.EmergenciesProblemGas leaking from cracked
Troubleshooting (continued)ProblemBurner(s) will not light using ignitor.(See Electronic Ignition Troubleshooting also)Burner(s) will notmatch light.
Troubleshooting - Electronic IgnitionProblem (Ignition)SECTION INo sparks appear at any electrodes when Electronic Ignition Buttonis pressed; no noise
WARNINGCALIFORNIA PROPOSITION 651. Combustion by-products produced when using this product contain chemicals known to the State of California to cause
NOTES30
Warranty Registration DepartmentP.O. Box 1240Columbus, GA 31902-124031
• NEVER store a spare LP cylinder under or near the appliance or in an enclosed area. • Never fill a cylinder beyond 80% full.• An over filled or impr
WARNINGIf “growing” bubbles appear do not use or move the LP cylinder. Contact an LP gas supplier or your fire department!Connecting Regulator to the
6.Turn the coupling nut clockwise and tighten to a full stop. The regulator will seal on the back-check feature in the LP cylinder valve, resulting in
7WARNINGFor Safe Use of Your Grill and to Avoid Serious Injury:• Do not let children operate or play near grill. • Keep grill area clear and free from
8Match-LightingCAUTIONIf ignition does NOT occur in 5 seconds, turn the burner controls OFF, wait 5 minutes and repeat the lighting procedure. If the
9 CAUTIONStoring Your Grill•Clean cooking grates.•Store in dry location.•When LP cylinder is connected to grill, store outdoors in a well-ventilated
Comments to this Manuals